Influence of high-volume water treatment plant sludge powder on strength and microstructure of concrete
-
摘要: 以煅烧后的自来水厂污泥粉 (CWTS) 取代部分水泥制备大掺量污泥粉混凝土，研究了大掺量 CWTS对于混凝土强度、孔结构和纳米力学性能的影响。结果表明：尽管大掺量CWTS不利于混凝土的28天抗压强度发展，但是20wt%和40wt%的CWTS能够增强混凝土的90天抗压强度；由于CWTS的火山灰活性和填充作用，掺有20wt%~40wt%CWTS的混凝土90天孔结构被明显细化，大于1 µm的孔隙含量明显减少；同时，从纳米尺度特征中观察到掺加20wt%CWTS能够明显降低基体中孔隙相和未水化相含量，并提高C—S—H相的体积分数，特别是高密度C—S—H相；此外，掺加20wt%的CWTS能够使界面过渡区(ITZ)宽度相对降低20%，并且掺加40wt%CWTS的实验组与对照组 (0wt%CWTS) 具有相似的ITZ宽度。由此可见，使用大掺量 (20wt%~40wt%) CWTS取代水泥制备混凝土，不仅具备较好的经济和环境效应，也有益于其90天力学性能和微结构的改善。Abstract: The calcined water treatment plant sludge powder (CWTS) was used to replace part of the cement to prepare high-volume sludge concrete, and the effect of the high-volume CWTS on the mechanical properties and microstructure of concrete was studied. The results show that although the high-volume CWTS is detrimental to the development of the 28-days compressive strength of concrete, 20wt% and 40wt% of the CWTS can significantly improve the 90-days compressive strength of concrete. The CWTS has pozzolanic reactivity and filling effect, which makes the 90-days pore structure of concrete mixed with 20wt%‒40wt%CWTS significantly refined, and the harmful pore volume (>1 µm) is significantly reduced. Meanwhile, it is observed from the nanoscale characteristics that adding 20wt%CWTS can significantly reduce the content of pore phase and unhydrated phase in the matrix, and increase the volume fraction of C—S—H phase, especially the high-density C—S—H phase. In addition, the addition of 20wt%CWTS can reduce the width of the interface transition zone (ITZ) by 20%, the addition of 40wt%CWTS and the control group (0wt%CWTS) have similar ITZ width. Therefore, using a large amount (20wt%‒40wt%) of CWTS to replace cement to prepare concrete not only has better economic and environmental benefits, but also benefits the improvement of its 90-days mechanical properties and microstructure.
-
图 2 纳米压痕混凝土试样的制备流程
Figure 2. Flow chart of nanoidentation concrete specimen preparation
R—Roughness
图 4 CWTS掺量对于混凝土孔结构的影响：(a) 累计孔隙率；(b) 不同尺寸孔隙的比例
Figure 4. Effect of CWTS on pore structure of concrete: (a) Cumulative porosity; (b) Proportion of different sizes of pores
图 5 不同CWTS掺量试件中水泥基体的90天弹性模量
Figure 5. 90-Days elastic modulus of cement matrix of sample with different CWTS content
图 6 CWTS对水泥基体弹性模量频率分布的影响
Figure 6. Effect of CWTS on frequency distribution of elastic modulus of cement matrix
MP—Micro-pores; LD—Low density; HD—High density; CH—Calcium hydroxide; UC—Unhydrated clinker
图 7 CWTS对水泥基体各相体积分数的影响
Figure 7. Effect of CWTS on volume fractions of constituent phases of cement matrix
图 8 不同CWTS掺量的试件界面过渡区 (ITZ) 的弹性模量分布云图
Figure 8. Contour map of elastic modulus distribution in interfacial transition zone (ITZ) of sample with different CWTS content
图 9 不同CWTS 掺量的试件界面过渡区宽度分布
Figure 9. Widths of interface transition zone of sample with different CWTS content
表 1 水泥和煅烧自来水厂污泥粉 (CWTS)的化学组成 (wt%)
Table 1. Chemical compositions of cement and calcined water treatment plant sludge powder (CWTS) (wt%)
CaO SiO2 Al2O3 Fe2O3 MgO SO3 Na2O MnO K2O P2O5 Cement 57.39 18.06 4.60 8.31 2.53 3.01 0.10 — 0.75 — CWTS 1.15 33.09 44.51 3.11 0.46 0.28 — 5.25 1.45 0.77 
下载: 导出CSV
表 2 混凝土配合比
Table 2. Mix proportions of concrete
Sample number Mass fraction
of CWTS/wt%Mix proportion/(kg·m−3) Cement CWTS Sand Coarse aggregate Water Super plasticizer C-0%CWTS 0 540 0 715 1040 162 9.8 C-20%CWTS 20 432 108 715 1040 162 10.7 C-40%CWTS 40 324 216 715 1040 162 13.4 C-60%CWTS 60 216 324 715 1040 162 15.2
下载: 导出CSV
-
[1] BONTON A, BOUCHARD C, BARBEAU B, et al. Comparative life cycle assessment of water treatment plants[J]. Desalination,2012,284:42-54. doi: 10.1016/j.desal.2011.08.035 [2] PATEL H, PANDEY S. Evaluation of physical stability and leachability of portland pozzolona cement (PPC) solidified chemical sludge generated from textile wastewater treatment plants[J]. Journal of Hazardous Materials,2012(207/208):56-64. doi: 10.1016/j.jhazmat.2011.05.028 [3] WEI L, ZHU F, LI Q, et al. Development, current state and future trends of sludge management in China: Based on exploratory data and CO2-equivaient emissions analysis[J]. Environment International,2020,144:106093. doi: 10.1016/j.envint.2020.106093 [4] BUREK J, DARIN N. Life cycle assessment of grocery, perishable, and general merchandise multi-facility distribution center networks[J]. Energy Build, 2018, 174(1): 388-401. [5] 李升涛, 陈徐东, 张伟, 等. 基于长江下游超细疏浚砂的碱激发矿渣混凝土力学性能[J]. 复合材料学报, 2022, 39(1): 335-343.LI Shengtao, CHEN Xudong, ZHANG Wei, et al. Mecha-nical properties of alkali activated slag concrete with ultra fine dredged sand from Yangtze river[J]. Acta Materiae Compositae Sinica, 2022, 39(1): 335-343(in Chinese). [6] BENLALLA A, ELMOUSSAOUITI M, DAHHOU M, et al. Utili-zation of water treatment plant sludge in structural ceramics bricks[J]. Applied Clay Science, 2015, 118: 171‒177. [7] WOLFF E, SCHWABE W K, CONCEICAO S V. Utilization of water treatment plant sludge in structural ceramics[J]. Journal of Cleaner Production,2015,96:282‒289. [8] TEIXEIRA S R, SANTOS G T A, SOUZA A E, et al. The effect of incorporation of a Brazilian water treatment plant sludge on the properties of ceramic materials[J]. Applied Clay Science,2011,53(4):561-565. doi: 10.1016/j.clay.2011.05.004 [9] CREMADES L V, CUSIDO J A, ARTEAGA F. Recycling of sludge from drinking water treatment as ceramic material for the manufacture of tiles[J]. Journal of Cleaner Production,2018,201:1071‒1080. [10] SCRIVENER K, JOHN V M, GARTNER E M. Eco-efficient cements: Potential economically viable solutions for a low-CO2 cement-based materials industry[J]. Cement and Concrete Research,2018,114:2‒26. [11] SHI J, LIU B, HE Z, et al. A green ultra-lightweight chemi-cally foamed concrete for building exterior: A feasibility study[J]. Journal of Cleaner Production,2020,288:125085. [12] GOMES S D C, ZHOU J L, LI W, et al. Recycling of raw water treatment sludge in cementitious composites: Effects on heat evolution, compressive strength and microstructure[J]. Resources, Conservation and Recycling,2020,161:104970. doi: 10.1016/j.resconrec.2020.104970 [13] GODOY L G G D, ROHDEN A B, GARCEZ M R, et al. Valori-zation of water treatment sludge waste by application as supplementary cementitious material[J]. Construction and Building Materials,2019,223:939‒950. [14] GOMES S D C, ZHOU J L, LI W, et al. Progress in manufacture and properties of construction materials incorporating water treatment sludge: A review[J]. Resources, Conservation and Recycling,2019,145:148-159. doi: 10.1016/j.resconrec.2019.02.032 [15] AHMAD T, AHMAD K, ALAM M. Investigating calcined filter backwash solids as supplementary cementitious material for recycling in construction practices[J]. Construction and Building Materials,2020,175:664-671. [16] 中华人民共和国住房和城乡建设部. 混凝土物理力学性能试验方法标准: GB/T 50081—2019[S]. 北京: 中国建筑工业出版社, 2019.Ministry of Housing and Urban-Rural Development of the People’s Republic of China. Standard for test methods of concrete physical and mechanical properties: GB/T 50081—2019[S]. Beijing: China Architecture and Building Press, 2019(in Chinese). [17] HE Z H, ZHAN P M, DU S G, et al. Creep behavior of concrete containing glass powder[J]. Composites Part B: Engineering,2019,166:13-20. doi: 10.1016/j.compositesb.2018.11.133 [18] QIN Z, ZHOU S, MA C, et al. Roles of metakaolin in magnesium phosphate cement: Effect of the replacement ratio of magnesia by metakaolin with different particle sizes[J]. Construction and Building Materials,2019,227:116675. doi: 10.1016/j.conbuildmat.2019.116675 [19] HE Z H, DU S G, CHEN D. Microstructure of ultra high performance concrete containing lithium slag[J]. Journal of Hazardous Materials,2018,353:35‒43. [20] 刘巧玲, 李汉彩, 彭玉娇, 等. 多壁碳纳米管增强水泥基复合材料的纳米力学性能[J]. 复合材料学报, 2020, 37(4):952-961.LIU Qiaolin, LI Hancai, PENG Yujiao, et al. Nanomecgani-cal properties of multi-wall carbon nanotubes/cementitious composites[J]. Acta Materiae Compositae Sinica,2020,37(4):952-961(in Chinese). [21] WANG X, DONG S, LI Z, et al. Nanomechanical characte-ristics of interfacial transition zone in nano-engineered concrete[J/OL]. Engineering, 2021, https://doi.org/10.1016/j.eng.2020.08.025. [22] MAIERDAN Y, HAQUE M A, CHEN B, et al. Recycling of waste river sludge into unfired green bricks stabilized by a combination of phosphogypsum, slag and cement[J]. Construction and Building Materials,2020,260:120666. doi: 10.1016/j.conbuildmat.2020.120666 -
下载:
点击查看大图
计量
- 文章访问数: 513
- HTML全文浏览量: 257
- PDF下载量: 38
- 被引次数: 0
